国产AⅤ视频视频在线

<u id="aykpt"><span id="aykpt"></span></u>
<th id="aykpt"></th>
    <center id="aykpt"><em id="aykpt"></em></center><big id="aykpt"></big><del id="aykpt"><small id="aykpt"></small></del>
  1. <del id="aykpt"><small id="aykpt"></small></del>
  2. 當前位置:首頁 > 行業動態 > 超凈工作臺標準使用方法及日常維護(中英對照)
    超凈工作臺標準使用方法及日常維護(中英對照)
    發布時間:2011-12-31 15:42:14   瀏覽:8768

        超凈工作臺標準使用方法及日常維護

        本文著重對超凈工作臺的定義,超凈工作臺的運行原理,應用方法及超凈工作臺的日常使用維護做一個詳細說明!國內外讀者均可以方便閱讀本文!

       一、什么是超凈工作臺呢?

      超凈工作臺是一種局部凈化設備,即利用空氣凈化技術使一定操作區內的空間達到相對的無塵、無菌狀態。使用時,必須放置在潔凈的空間。其接種數量不受無菌空的限制,操作比較簡便,可以較大幅度地提高工作效率,適用于大規模生產。為了保證接種成功率,接種時使用酒精燈,效果更好。

        Clean Bench is a partial purification equipment, namely the use of air purification technology to a certain region of space operations to achieve a relatively dust-free, sterile condition. Used, must be placed in a clean space. The number of its vaccination is not sterile space constraints, the operation is simpler, can be more greatly improve work efficiency, suitable for mass production. In order to ensure the success rate of vaccination, inoculation using alcohol lamp, better.

     

      二、超凈工作臺運作原理及應用方法

      超凈工作臺的優點是操作簡單自如,較為舒適,工作效率高,預備時間短,開機十分分鐘以上即可操作,基本上可隨時使用。在工廠化生產中,接種工作量很大,需要經常長久地工作時,超凈臺是很理想的設備。超凈臺由三相電機作鼓風動力,功率145~260W左右,將空氣通過由特制的微孔泡沫塑料片層疊合組成的“超級濾清器”后吹送出來,形成連續不斷的無塵無菌的超凈空氣層流,即所謂“高效的特殊空氣”,它除去了大于0.3μm的塵埃、真菌和細菌孢子等等。超凈空氣的流速為24~30m/min,這已足夠防止附近空氣可能襲擾而引起的污染,這樣的流速也不會妨礙采用酒精燈或本生燈對器械等的灼燒消毒。工作人員就在這樣的無菌條件下操作,保持無菌材料在轉移接種過程中不受污染。但是萬一操作中途遇到停電,暴露在未過濾空氣中的材料便難以幸免污染。這時應迅速結束工作,并在瓶上作出記號,內中的材料如處于增殖階段,則以后不再用作增殖而轉入生根培養。如為一般性生產材料,因極其豐富也可棄去。如處于生根過程,則可留待以后種植用。

        Clean Bench has the advantage of easy to operate freely, more comfortable, efficient, preparation time is short, the boot can be operated for more than a very minute, basically ready to use. In factory production, inoculation heavy workload, the need for frequent long-term work, the Clean Bench is the ideal equipment. Clean Bench by the three-phase motor to make blast power, power 145 ~ 260W or so, will air through the porous foam by a specially composed piece cascading together a "super filter" after blowing out the formation of a continuous dust-free The ultra-clean air laminar flow bacteria, so-called "high-performance special air", which removed more than 0.3μm dust, fungi and bacteria spores and so on. Ultra-clean air flow rate of 24 ~ 30m/min, which are adequate to prevent possible harassment in the vicinity of air pollution caused by such a flow will not impede the use of alcohol lamp or Bunsen burner burning disinfection of equipment and so on. And in this way the staff operated under sterile conditions to maintain sterile material in the course of the transfer of vaccination is not contaminated. But what if an electrical outage halfway operation, exposed to unfiltered air contaminated material will not be spared. Should provide a speedy end to work and make a mark on the bottle, which is in the materials, such as the proliferation phase, we will no longer be used as a proliferation and transferred to rooting culture. As for the general production of materials, due to the extremely rich can also be disposable. As in the rooting process, can be planted until later use.

     

      超凈工作臺電源多采用三相四線制,其中有一零線,連通機器外殼,應接牢在地線上,另外三線都是相線,工作電壓是380V。三線接入電路中有一定的順序,如線頭接錯了,風機會反轉,這時聲音正?;蛏圆徽?,超凈臺正面無風(可用酒精燈火焰觀察動靜,不宜久試),應及時切斷電源,只要將其中任何兩相的線頭交換一下位置再接上,就可解決。三相線如只接入兩相,或三相中有一相接觸不良,則機器聲音很不正常,應立即切斷電源仔細檢修,否則會燒毀電機。這些常識應在開始使用超凈臺時就向工作人員講解清楚,免除不應造成的事故與損失。

        Clean Bench power supply to use more three-phase four-wire system, of which 10 lines, connecting the machine casing should then firmly on the ground line, the other three lines are the phase, the working voltage is 380V. Third-line access to the circuit in a certain order, such as pick the wrong end of a thread, wind the opportunity to reverse, when the sound normal or slightly abnormal, Clean Bench front without wind (available alcohol lamp flame observation of static and dynamic, not long-trial), should be promptly cut off the power, as long as any of them as two-phase end of a thread to exchange position were followed, the will be over. Three-phase line, such as access only to two-phase or three-phase there is a similar connection is bad, then the machine sounds very normal, should be immediately cut off the power supply careful maintenance, otherwise they will burn motor. These common sense should be when they start using Clean Bench to explain clearly to staff, should not result in exemption from the accident and loss.

     

      超凈工作臺進風口在背面或正面的下方,金屬網罩內有一普通泡沫塑料片或無紡布,用以阻攔大顆粒塵埃,應常檢查、拆洗,如發現泡沫塑料老化,要及時更換。除進風口以外,如有漏氣孔隙,應當堵嚴,如貼膠布,塞棉花,貼膠水紙等。工作臺正面的金屬網罩內是超級濾清器,超級濾清器也可更換,如因使用年久,塵粒堵塞,風速減小,不能保證無菌操作時,則可換上新的。

        Clean Bench at the back or front air inlet below the metal mesh cover within a normal foam piece or non-woven fabrics used to block large particles of dust, should be a routine check, unpick and wash, such as found in foam aging, must be promptly replaced. In addition to outside air inlet, where gas leakage pores, it should be blocked strict, such as patching, plug of cotton and paste glue paper. Table inside the front cover of the metal mesh filter is super, super filter may be replaced, as a result of the use of long years, dust jam, wind speed decreased, can not guarantee aseptic operation, can be replaced with new.

        超凈臺使用壽命的長短與空氣的潔凈程度有關。在溫帶地區超凈臺可在一般實驗室使用,然而在熱帶或亞熱帶地區,由于大氣中含有高量的花粉,或多粉塵的地區,超凈臺則宜放在較好的有雙道門的室內使用。任何情況下不應將超凈臺的進風罩對著開敞的門或窗,以免影響濾清器的使用壽命。

        Clean Bench length of life related to the degree of air cleanliness. Clean Bench in temperate regions may be in the general laboratory use, but in tropical or subtropical regions, because the atmosphere contains high levels of pollen, dust or more areas, Clean Bench are advised to put a better interior double doors. Any case, Taiwan should not be ultra-clean air inlet hood facing the open door or window, so as not to affect the filter life.

     

      無菌室應定期用70%酒精或0.5%苯酚噴霧降塵和消毒,用2%新潔爾滅抹拭臺面和用具(70%酒精也可),用福爾馬林(40%甲醛)加少量高錳酸鉀定期密閉熏蒸,配合紫外線滅菌燈(每次開啟15分鐘以上)等等消毒滅菌手段,以使無菌室經常保持高度的無菌狀態。接種箱內部也應裝有紫外線燈,使用前開燈15分鐘以上照射滅菌,但凡是照射不到之處仍是有菌的。在紫外線燈開啟時間較長時,可激發空氣中的氧分子締合成臭氧分子,這種氣體成分有很強的殺菌作用,可以對紫外線沒有直接照到的角落產生滅菌效果。由于臭氧有礙健康,在進入操作之前應先關掉紫外線燈,關后十多分鐘即可入內。

     

        Sterile room should be on a regular basis with 70% alcohol or 0.5% phenol spray dust and disinfected with 2% wiped countertops and appliances Bromogeramine (70% alcohol can also be), with formalin (40% formaldehyde) plus a small amount of high manganese airtight fumigation potassium on a regular basis to meet the ultraviolet sterilization lamps (each to open more than 15 minutes) and so on means of disinfection and sterilization, sterile rooms in order to maintain regular high level of sterility. Vaccination should also be equipped with a UV box inside lights, turn on the lights more than 15 minutes prior to use radiation sterilization, but not of the Department any exposure there is still bacteria. UV light to open longer, it can stimulate oxygen molecules in the air to enter the ozone molecule synthesis, this gas composition has a strong bactericidal effect, you can not directly shine on the corner of ultraviolet sterilizing effect produced. Because ozone unhealthy, on entering the operation should be preceded by turn off the UV lamp off after more than 10 minutes you can enter.

     

      在超凈工作臺上亦可吊裝UV紫外線燈,但應裝在照明燈罩之外,并錯開照明燈平行排列,這樣在工作時不妨礙照明。若將紫外線燈裝入照明燈罩(玻璃板)里面,這是毫無用處的,因為紫外線不能穿透玻璃,它的燈管是石英玻璃,而不是硅酸鹽玻璃制成的。

     

         In the ultra-clean the table can also be hoisting UV ultraviolet light, but it should be packed in light shade outside, and stagger the lights arranged in parallel, so that at work, without prejudice to lighting. Ruoqiang ultraviolet light into light shade (glass) inside, which is useless, since ultraviolet light can not penetrate the glass, it is a quartz glass tube, rather than made of silicate glass.

     

      接種室內力求簡潔,凡與本室工作無直接關系的物品一律不能放入,以利保持無菌狀態。接種室內的空氣與外界空氣應絕對隔絕,預留的通氣孔道應盡量密閉。通氣孔道可設上下氣窗,氣窗面積宜稍大,需覆上4層紗布作簡單濾塵。在一天工作之后,可開窗充分換氣,然后再予以密閉??傊?,既要清潔無塵無菌,又要空氣新鮮,適宜工作。覆在通氣窗上的紗布應經常換洗。但是上述種種措施只是理想的設計方案,往往不易全面做到,其實只要嚴格無菌操作手續,在門窗敞開的室內,有一超凈臺的保護,接種的污染率仍可控制在生產上可以容忍的水平。

      

      三、超凈工作臺的日常維護

        Third, the daily maintenance of ultra-clean bench

     

      超凈工作臺是一臺較精密的電氣設備,對其進行經常性的保養和維護是非常重要的。

        我們怎樣做好保養凈化設備的最重要的超凈工作臺工作呢?

     

      首先要保持室內的干燥和清潔,潮濕的空氣既會使制造材料銹蝕,還會影響電氣電路的正常工作,潮濕空氣還利于細菌、霉菌的生長。清潔的環境還可延長濾板的使用壽命。

     

      另外,定期對設備的清潔是正常使用的重要環節。清潔應包括使用前后的例行清潔和定期的熏蒸處理。熏蒸時,應將所有縫隙完全密封。清潔應包括使用前后的例行清潔和定期的熏蒸處理。熏蒸時,應將所有縫隙完全密封,如操作口設有可移動擋板封蓋的類型超凈工作臺,可用塑料薄膜密封。

     

      超凈工作臺的濾板和紫外殺菌燈都有標定的使用年限,應按期更換。

     補充一點:在使用超凈工作臺的工程中,要注意不要有相關的震動產品,會影響到工作臺內部的風機使用壽命!

    相關產品:垂直流超凈工作臺  產品所有:http://www.judi36.com 蘇小姐:13570963006

    上一篇:公司介紹 下一篇:超凈工作臺的原理及操作方法說明(整理版)...
    国产AⅤ视频视频在线
    <u id="aykpt"><span id="aykpt"></span></u>
    <th id="aykpt"></th>
      <center id="aykpt"><em id="aykpt"></em></center><big id="aykpt"></big><del id="aykpt"><small id="aykpt"></small></del>
    1. <del id="aykpt"><small id="aykpt"></small></del>